The failure occurred intermittently while driving at any speed. One day in June I was pulling up to a store parking space rolling roughly 5mph. To restart, must shut car off, key out and it will restart. The contact owns a 2006 Ford Five Hundred. Pmb. The contact opened the hood and flames emerged from the engine and the smoke turned black. Luckily there were no other cars near me. The most recently reported issues are listed below. Members can start their own topics & subscribe to topics Engine light, oil light and something else came on. Service Engine light then came on and so I got it started again and took it immediately to the nearest auto shop. . On the way home from the movies late one evening my Escape just cut out on the expressway. See no warning lights at time. every now and then truck shuts off while driving. Our harness is an upgraded, direct replacement for the GM 15862656 and the AC Delco PT2195. Please keep us posted on what you find. When in drive it hoes away. Time will pass and it will eventually come back on, after a couple weeks. Car Won't Start When I Turn The Key I Here It Start And Then It Stalls Out. The contact stated that while driving 10 mph, the vehicle stalled without warning. Updated 03/24/lj They issued memo's to their stores, (which I have copies of) but NEVER sent a letter to the owners. My car started chugging and running rough so I figured it was another coil. Ford Forum is a community to discuss all things Ford. Park the truck nose down. happened last month i chnaged throttle body and had had pcm updated still going limp and wrench light still comes. While driving various speeds, the vehicle suddenly accelerated independently and there was a sudden increase of engine rpms. [DROF_3380] 02 Ford Excursion Fuse Diagram Fuse Diagram - OSSIE. 2005 Ford Five Hundred Electrical System Problems | | Page 3 only code that comes up is number 6 injector. It Now Won't Even Start A Little, The Warning Says Low Oil Pressure. I restarted the engine and 'limped' homein second gear. I had to pull over and shut the car off. Even though I have a 2007 model year, the car was manufactured in 2006 and the cluster is the problem. 5 screws if I remember correctly. Would start up but could not go over 10 miles per hour. all problems of the 2006 Ford Five Hundred FORD FIVE HUNDRED 2005 OWNER'S MANUAL Pdf Download The contact stated that while driving 70 mph, the wrench warning indicator illuminated as the vehicle stalled. We were going approximately 45 miles an hour on a two lane road through the mountains when my Explorer decides to turn off. I've seen more electrial issues that turned out to be a weak battery. The vehicle was taken to a independent mechanic for diagnosis. after I was happy that it had crunk up an was running again, so I changed it imediately and crank it up and same thing happens again. The manufacturer was not made aware of the issue. All site content Copyright 2004-var year=new Date(); year=year.getYear(); if (year<1900) year+=1900; document.write(year); FordTaurus.net We are in no way affiliated with Ford Motor Company. I came around and peered in behind the actual mirror part; the fire had just gone out. I guess you have to change both pumps so that the left pump will know what the right pump is doing. Page 1 Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Moon roof Message center Locks and Security Keys Locks Anti-theft system 2007 Five Hundred (500) Owners Guide (post-2002-fmt) USA (fus) Page 2: Table Of Contents The manufacturer was not notified of the failure. . Next evening, turned on ignition and the Escape starts running rough in the driveway. Suppose I was going 60mph, I would have lost control of the vehicle. We have replaced the fuel pump and spark plugs. The vehicle was taken to a local mechanic for inspection. The batt light goes on and the entire instrument cluster (spedo fuel turbo temp etc ) shuts off .. when it's off the climate control won't work and the sun roof won't work . Waited 2 min. Truck has to be shut off and started with cluster on. Many people's description of a defective transmission body matches our description, but that part is, apparently, on backorder. No wonder there has been one the parking lot where my co-worker picks me up.. w/flat tire for a month. 2005 F350 6.0 shut off while driving. HELP! - Ford Powerstroke Diesel Forum 2005 Ford Five Hundred Review - NewCarTestDrive Suddenly on the road I experienced loud engine chugging over 45mph, a blinking check engine light (could barely be seen then it was off again), and so I immediately attempted to coast home (less than a mile away) to have a mechanic check it out during business hours. When I ok'd that repair, the dealership called back later and stated it was the entire throttle body and repair would come at a cost of $1000. it is extremely dangerous! I called Ford to let them know that this has happened 4 times now and it is a MAJOR safety issue! If this is happening to Explorers, Freestyles, Mustangs and many other makes and models maybe the throttle body assembly was made by the same mfg. The mechanic advised the contact that the air conditioning system needed to be replaced. FORD FIVE HUNDRED OWNER'S MANUAL Pdf Download | ManualsLib Do Not Sell or Share My Personal Information, 2006 F150 5.4 Sputtering - New thread CONDENSED, https://www.morepowertuning.com/how-to-idle-relearn. When this happens the reverse lights come on even when in drive. I Was Driving It On The Hwy When The Truck Just Turned Off. wow~ this is one i've never heard before. the contribution test injector is firing right. I have a 2007 Ford Five Hundred with 21K miles. I always have to be extra careful. Ford Five Hundred Vehicles With This Problem - RepairPal and started it again. The failure occurred intermittently while driving at any speed. Shutting off while driving! Car stalled out 2 times on the way to the dealer. When you change the normal fuel pump you have to change the left pump too. Please issue a recall on the instrument panel replacement. The car is essentially un-drivable, because we cannot count on it to get to us work on time or safely. While driving the dash board goes dead and all of the gauges go to zero. problems related to car stall (under the engine and engine cooling category). Who buys a car to keep dumping cash into it & burdening people for rides?????? Pulled over, turned the ignition off and back on and it was fine. While driving about two weeks ago, the little wrench light came on and I lost power. This car has had so many issues, never again will I buy a FORD!! Get notified about new defects, investigations, recalls & lawsuits for the. I have two vehicles, same year, make and model that do the exact same thing. Days lights flicker. I can't keep buying and replacing coils on this thing since it's not paid off and in my bankruptcy I can't trade it in either. The fire department extinguished the fire; however, the fire erupted again and would not stop until the battery was disconnected. On day 6 I accelerated to 50mph and the dash lit up like a christmas tree and just stalled. by tmac1180 Mon Nov 01, 2010 7:14 pm, Post Kw. The manufacturer was notified who advised that there were no recalls for the vehicle and offered no other assistance. The Fora platform includes forum software by XenForo. I looked on here and it seems a lot of Escapes have the same problem. Although the car is ten years old now, it is really very low in mileage so as to face this kind of problem. Cluster will Randomly shut off while driving? - Ford F150 Forum I think corrective action should be taken towards a resolution. I'm Sick, Frustrated, angry, about to lose my job, what else? The car rolls under its mass. Almost rear ended and had no idea what to do. NOT ACCEPTABLE FORD and my wife and I will not be giving you ANY business in the future as my 4th Ford product in 15 years will now be something other than a Ford with 100K and a 10 year warranty from a competitor. They could not get any codes out of it so then the guessing game started. At the very least, get a hold of a diagnostic scanner, plug it into the OBD-II connector (located under the dash to the left of the steering column), and get any codes that are stored. per internet research this is happening in several Ford models and stems from a bad solder joint. The cluster will turn off ( tac, speedo, gas guage, ect ) Then all the warning lights will come on at the same time and stay light up ( 4x4, abs, engine, parking brake ect ) The odometer will just be blank ( it is still lit up but no mileage is shown ) Tac, speedo, and all my gauges look as if the truck is off 2005 - 2007 Ford Five Hundred Throttle Body Problems DIY Auto Homeschool 18.7K subscribers Subscribe 1.2K Share 96K views 3 years ago In this video, we are dealing with throttle body issues on. All the issues pointed @ a PATS problem. Get notified about new defects, investigations, recalls & lawsuits for the. The vehicle will lunge out even when the brake is pressed. Your Focus's engine needs three things to run properly; air, fuel, and spark. Once again..$120 EACH or about $750 at their prices. I have owned my 2006 Ford 500 for 5 yrs and have had and issue for the last 2 yrs. If you get one from the salvage get them from the same car. My next stop was to get two propane tanks filled. All the alarms went off and the check engine light came on before the power failed. While driving various speeds, the vehicle suddenly accelerated independently and there was a sudden increase of engine rpms. Looking at it, I could see it was the security light on the bottom side of the mirror; it was completely melted and fused to the mirror housing- a bubbly mess of plastic. Still have a short somewhere . My wife, son and I were driving. The car vibrated and the engine ran jerky not smooth, and sputtered as I drove it about 2 miles to my house. 5.4 shutting off while driving. My car is fine and then I go to start the car it won't start. I dont feel safe driving my car I put 2000 dollars of work and still do not feel save. The oil has been changed, air filter, radiator fluid, battery good. When the car comes to a natural stop and you were lucky enough to survive the situation, Shift the gear from D to P and turn the ignition you are back on the road again.. I have a 2006 mustang that within the last six months has started to shut off while I'm driving. Then at pharmacy drive thru w car I. truck runs fine. Had the battery reset had no impact on the problems I would say it's a mechanical matter, but it seems clear its a computer or electrical issue. The vehicle was restarted but the failure continued to recur. The vehicle was restarted but the failure recurred. This is a flaw w Ford 500 2005 throttle body many complaints and test does never issues recall, unsafe. When I Turn The Key I Here It Start And Then It Stalls Out. I have a 2002 f250 5.4 and while I am driving it just cuts off. Have a 2005 Ford Escape on my out of town car stopped. This, as well as no speedometer to me is very dangerous. No warning whatsoever. So, OPTION B.spend $200 for the used cable, let the Ford tech. your side mirror is on fire! I then saw the smoke billowing to the left (a strong afternoon breeze was blowing north). I do not think it should be my responsibility to pay for this since the part was recalled !!! Ford should at least offer the computer at a discount. It was a very scary situation. Cluster panel just shuts off while running and can't use air, radio, windows, locks, seats, etc. Engine light, oil light and something else came on. 2005 Ford Five Hundred Engine Stopped Running While Driving. Once they got the engine codes " reloaded " and tried to start it..guess what4 coils were blown out and the car would barely run. This process repeats on and off over time. The Engine Will Turn Over But It Will 1994 Motorhome Fuel Pump In Tank Is Bad. Isn't Ford a big enough company to take care of this instead of ignoring it? Also, when using cruise control, the whole car shakes and stutters slightly when going up or down very slight inclines. I managed to get it to my mechanic. And I dont know what to do about this problem. 2005 Ford Five Hundred Asked by Shanae8 in Chesterfield, VA on August 01, 2016 I had my Ford 500 3mos, at first all dash board lights would go outand maybe come back on the same day. on October 19, 2016. Used a different key next day, drove to work,home & out to run errands. But on a hot day (90+) when moving from a stopped position out of a parking spot or around a corner, when you lightly have the brake pedal depressed if you turn the wheel slightly (ie backing out of a tight parking space) the car will lunge violently and aggressively in what ever direction you are traveling, sometimes so aggressively it will stall the vehicle out and then go into a failsafe mode. I refused to pay that. all problems of the 2005 Ford Five Hundred The underside of the mirror had caught fire and started burning for a bit before the fuse finally blew. The vehicle was not further repaired. . 1)The car loses power and shuts down temporarily while driving. The contact was able to shut off and restart the vehicle in order to operate normally. I again did the battery disconnect last night, and the car is operating normal today, but I'm sure it will recur shortly. So the first thing I did was open the hood and make sure nothing was on fire. Anyone know of recalls to this problem? I called her and had her send the part over at HER PRICING of $820 total. The vehicle that I have is a 2005 Ford F-150 4x4 with a 5.4 litre engine. . Marcus, the service manager informed me a new wiring harness was now needed since the original one was melted by the PCM shorting out. by racingrush Wed Nov 03, 2010 3:59 am, Post I ran a scan tool on it figuring maybe the fuel filter or ground wire maybe but nothing showed up that would cause the car to quit running like this. Gauges drop check engine light comes on then wrench light then one shaped like a car n starts loosen power. The left fuel pump help maintain the pressure in the tank and the fuel rail which allow the car to run sometime with no problems and then stall with no warning or stumble. Pulled over and shut car off and restarted it again a few minutes later and everything was fine. Check out our discussions on the Ford Escape, Mustang, Edge, F-150, Raptor, Explorer, Focus, Fusion, Fiesta and more! Four coils are bad and it burned the circuit board or whatever you call it. All I could think about was to move over into the right lane and get off the road somehow. Now driving back to normal. This has happened multiple times (meaning more than 5 times) during the summer of 2011. I am typically not one to complain, but I feel very strongly about the safety of this vehicle, especially since I have a 3yr old daughter. It has done this in parking lots and while driving. Dashboard lit up and immediately lost all power to car. Now it cuts off while driving and reverse light on while dash is out 0 replies Report Answer Get it fixed today at a shop near you Driving Procedure: Release pressure in the fuel tank by removing and re-installing fuel cap. Go to another state & leave it there. I had no where to turn off, no power steering, and very little braking power. HELP. I was driving on freeway to pick my child from daycare when all the sudden the car stalled out. I have taken in to dealership and explained these "symptoms" but they just say they don't know what it could be and will have to check it out while it is happening. The contact stated that while at a stop light, the vehicle stalled without warning and shifted into reversed independently. all problems of the 2007 Ford Five Hundred 6.0L Power Stroke Diesel - 6.0 randomly shuts off - 04 with 170k miles. You need to get a new cluster and replace the old one. The contact stated that the instrument cluster dimmed intermittently which made it difficult to see the display. problems related to electrical system (under the electrical system category). This vehicle has had a surging and stalling issue ever since it was purchased. I could have killed someone. Have replaced all parts suggested by codes. also, check the battery. Update from Apr 24, 2015: I want this moved to computer_PCM_failure (91 complaints) instead of in the engine section. This was the first of many times this occurred! Our car stalls while driving. 2006 Ford Five Hundred Limited Shuts Off While Driving - Ford Taurus Cost $1800. The vehicle was not further repaired. I was driving about 40 mph, and my car just randomly died after all the dashboard lights flashed on. The vehicle has not been repaired. It appeared, at first, that this problem had come out of nowhere when I suddenly remembered two occasions when the rpms suddenly stuck on 3000 and would not stop until I put the car in neutral. Back of me car did same thing. HELP! The vehicle had not been repaired. The fail safe mode warning light started to illuminate. He quickly discovered it was a computer problem and it needed to be replaced. I will not be buying a Ford ever again. I also let them know that my family has worked at Ford for generations now and I would hope they would at least look at it and do something about this extreme danger. My son's 2010 with the 5.4 was doing this. Instrument cluster not working. spent so much money and time trying to figure out problem. 2005 ford 500 wrench light, changed throttle body, updated PCM still going limp on me 16 Answers. So yet 1 more call to my daughter for 4 coils at her discounted employee pricing. Designation of fuses and relays in Ford F250, F350, F450, F550 from 2002 to 2008. f150 fuse 2004 box ford lariat start turn starter diagram wiring lights question ask own [DIAGRAM] 2012 Ford Explorer Fuse Box Diagram FULL Version HD Quality geinokaigi. The battery will just die and stop holding a charge. Car stalls while driving. The manufacturer was made aware of the failure. JavaScript is disabled. The problem might be with a defective crankshaft position sensor. SET YOUR VEHICLE Get an exact fit for your 2007 Chevrolet Silverado 1500 Make Model. Mechanic suggested I try putting claim in with insurance company since it involved computer burn but they said mechanical problem was the cause so no coverage. I had a bad no-start situation because the key was only working when inserted just the right way. The vehicle was taken to a dealer who diagnose that the throttle body sensor needed to be replaced. Still occurs. The engine was still running and would accelerate. At the time I chalked it up to being low on gas, although according to the gauge I still had a few gallons left. The contact owns a 2005 Ford Five Hundred ltd. The RES control will not work if the CNCL vehicle speed is not faster than 30 mph (48 km/h). PCM ( power control module ) was fried according to service manager after spending a day " diagnosing " and running volt/ohm checks on everything. Here is the fix, ford has to fuel pumps, under the rear seat there two openings, driver side is called a left pump, not available at any parts store, dealer or salvage. You must be able to get it stopped on the side of the road and shut the car off and then restart it to correct the problem for a short period of time. Then google each code (and/or post them here) to gain additional information as to why the engine is shutting down. It doesn't matter if I'm driving fast on the freeway or slowing down to a stop. If the key is not removed, it will not restart. Consumer stated the left front head light caught on fire spontaneously while having been parked for 30 minutes in the garage and engine was off. I was driving 35mph and all of a sudden my car had no power, I gave it gas and it would growl but no power. The vehicle had random acceleration while at full stopped. Put in new fuse it blew. Wont shift from first gear after cluster panel shuts off. Without touching the gas my 2005 Ford Five Hundred lunged at the building as if the throttle was stuck wide open! Shutting off while driving! The vehicle would then be towed to an authorized dealer where they were always unable to diagnose the failure. Door froze shut and ever since manually opening the message center states driver door ajar and passenger door ajar and they are not. The Life of a Man 2.96K subscribers Subscribe 645 Share 203K views 5 years ago Quick video to show a temp fix. I had the work done at an independent repair shop. Drove it home and have not taken it out since. So far we are at $5000 just for the parts. I am very good to my car so now what. 2005 ford five hundred. The approximate failure mileage was 49,000. 2006 Ford Five Hundred. all problems of the 2007 Ford Five Hundred Had fuel filter replaced. Follow directions how to clear failsafe and implement them. finally got it started by holding brake and pushing on accelerator while putting it into drive so that it would not stall out. I had already replaced 2 coils at 300 a whack. 2005 FORD FIVE HUNDRED 90,000 MILES Car stalls while driving. It's in perfect condition except for one thing. Ford Five Hundred Questions - 2005 ford 500 wrench light, changed This problem resulted in a $700 repair bill. After stopping the car, I waited a few seconds and restarted it. The contact coasted the vehicle to the side of the road, turned it off and restarted it. No warning what so ever. I need your help before I waste thousands of dollars for me to just junk this big paper weight. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. I Was Driving One Day And My 1994 Ford Aerostar 3.0 V6 Suddenly Lost All Power And Would Not Start After. Cant afford to keep struggling with issues. It was very unsafe. 3 Recalls for 2005 FORD Five Hundred When we try to restart the car it will sputter and die again. It is completely random and you never know when or if it will happen. . 2005 Ford Explorer Engine Stalls/Shuts Off While Driving Yesterday the check engine light came back, and the car was running poorly (creeping when first off brakes, not up shifting), when the dash was operable it showed alternating check engine/check transmission warnings, and vehicle was surging/lagging noticeably at highway speeds. For a better experience, please enable JavaScript in your browser before proceeding. When I drove it to my mechanic, it did the same thing but began flickering on and off the whole way there. install it and then test the new PCM. Ford Five Hundred - Wikipedia This problem may be covered under warranty. There was no power steering and I believe I could have had an accident if I wasn't strong enough to turn the steering wheel in order to get off the road. This is dangerous and should be an electrical recall. register to join our community Part of an ongoing series of issues with this vehicle (see earlier reports), initial symptom was the dash lights & needles shutting off intermittently (but now for extended periods). Happened a third time at the store. I brought it back to where I bought it and they said computer was fried. In this case, it's usually fuel. But I can't reset driver controls until doors show closed. I then pull over wait for 10 seconds to 2 min and it starts back up. Has this guy ever hear of stored fault codes? I Have A 2001 Ford Explorer Sport Trac. My mechanic called the dealership expecting Ford had a recall or would do something to help since it's clearly a problem with this particular year. Escape had not exhibited any issues going home. 10/17 will bring once they get them installed and try starting it one more time. Thanks for the info about the bulletin. Can seem to run fine, be in the middle of an intersection and the car shut off and wouldnt restar good thing I can drive and knew what to do or I would have crashed numerous times. They can go bad right out of the box. It wouldn't start again. CK Engine light came on SOLID this time and as I started to pull off the highway onto the shoulder, once again the engine died. Out of Fuel. I am keeping ALL of the paperwork on this little " open check book " EVENT with Ford as I smell a class action law suit brewing in the near future with their less than stellar " customer service " on this obvious RECALL event. It began with the 12 volt not working. I own a 2005 Ford Five Hundred there was a recall in 2012 on the throttle body, a Ford dealer supposably cleaned the throttle body, well now its not driveable. Of course the coverage ended on 03/31/2013. Ask your Ford dealer. 2005 FORD Five Hundred Subscribe to alerts for a 2005 FORD Five Hundred Submit a complaint about a 2005 FORD Five Hundred These recalls apply to the make, model, and year of your car - and should be fixed as soon as possible. While reversing my car it will all of a sudden accelerate quickly on its own, I immediately step on the brakes and my car stalls. I have also had an idling problem. This process repeats on and off over time. Car Shuts Off While Driving: Hello, I Have a Huge Problem with My It was very shaky. As a side note, I ran the on-board diagnostic (that you get to through the setup feature on the steering wheel) and it found no problems. My car has roughly 62,000 miles on it. I have looked my car up to see if it has a recall but none are given. I took to auto zone the day it went haywire & they advised me its a possible recall several ppl said the same issue with their Ford. SOLVED: Ford 500 - 2005 - The entire dash (all gauges) wen - Fixya It has recurred a few times, its most noticeable after dark as dash lights go black. Please note that whenever the vehicle is on park and put into reverse, the higher acceleration takes place.

San Diego Unified School District Staff Portal, Isuzu Grafter Wheel Nut Torque Settings, Stv News Presenters Female 2020, Articles OTHER